Elf Bar AF5500 Pod Kit

The Elf Bar AF5500 prefilled pod kit took over from the AF5000 when disposables got pulled in June 2025. Bigger battery at 1000mAh instead of the old 650mAh, USB-C charging, and approximately 5,500 puffs from each pod and refill container. The 1.2ohm QUAQ mesh coil is the same one the AF5000 used.

Each Elf Bar AF5500 kit ships with a 2ml pod and a 10ml refill container holding 20mg ElfLIQ nic salt. Ten Elf Bar AF5500 pod flavours in the range covering fruit, ice, and menthol. Pod and container click into the kit together and the e-liquid feeds through on its own as you vape.

Key Features

• Approximately 5,500 Puffs from the 2ml pod and 10ml refill container (varies with usage)
• 1000mAh Battery up from 650mAh on the AF5000, lasts a full day on MTL
• QUAQ Mesh Coil 1.2ohm, same coil as the old AF5000
• Auto-Refill e-liquid feeds from the container into the pod while you vape
• 20mg Nic Salt ElfLIQ e-liquid, 12ml total per kit
• See-Through Body check your e-liquid level without guessing
• Inhale Activated no buttons, draw to vape
• 10 Flavours available as Elf Bar AF5500 refill pods

Elf Bar AF5000 vs AF5500

Still searching for the Elf Bar AF5000? This is what replaced it.

The coil, flavours, draw, and nic salt strength are all carried over. What's changed is the battery and the fact you swap pods instead of binning a working vape every few days. 

1000mAh Battery and USB-C Charging

A 1000mAh battery in the Elf Bar AF5500 goes a full day for most MTL vapers. That's nearly double what the AF5000 had at 650mAh, so you're not running flat halfway through the afternoon like the old one sometimes did.

USB-C on the base takes roughly an hour to charge from empty. The LED on the front tells you where you're at with the battery. No cable in the box though, so any USB-C phone charger does the job.

QUAQ Mesh Coil and Auto-Refill

Inside each Elf Bar AF5500 pod there's a 1.2ohm QUAQ mesh coil that heats e-liquid across a wider surface than a standard round coil would. In practice that means the flavour doesn't tail off towards the end of the pod the way it can with cheaper kits.

E-liquid management is handled by the auto-refill container. The 10ml container sits in the base and feeds liquid up into the 2ml pod through capillary action as you vape. You'll spot small bubbles rising through the see-through body when it's working. Between the pod and container you've got 12ml of ElfLIQ nic salt, which is where the approximately 5,500 puff count comes from.

One thing worth knowing: this is a prefilled kit, not a refillable one. You can't open the pods or top them up with your own e-liquid. When everything's empty you swap in a fresh Elf Bar AF5500 refill pod set and you're good to go again.

Elf Bar AF5500 Flavours

Ten Elf Bar AF5500 flavours right now, all prefilled with 20mg ElfLIQ nic salt. These are the same flavours that were in the AF5000 range.

Browse the full Elf Bar AF5500 refill pods collection for every flavour in stock.

Elf Bar AF5500 Specifications

How to Set Up the Elf Bar AF5500

1. Take the Elf Bar AF5500 kit and refill the container out of the box.
2. Unscrew the lid from the 10ml container but leave the rubber stopper underneath it.
3. Pull the silicone bung out of the base of the AF5500 kit.
4. Push the container into the base until you feel it click.
5. Turn the whole thing upside down and leave it for about 5 minutes. 
6. Flip it back upright, wait another 30 seconds, then draw on the mouthpiece.
7. When the pod runs empty, pull it out and slot a fresh Elf Bar AF5500 refill pod in the same way.

No USB-C cable in the box. Grab one from a phone charger or order separately.

What's in the Box?

• 1x Elf Bar AF5500 Kit (1000mAh battery, LED indicator)
• 1x 2ml Prefilled Pod with 1.2ohm QUAQ mesh coil (pre-installed)
• 1x 10ml Refill Container with 20mg ElfLIQ nic salt
• 1x User Manual
• USB-C cable not included